Abstract This work aimed to compare the production of collagenolytic proteases produced by M. subtilissimus UCP1262 in submerged fermentation (SF) and solid-state fermentation (SSF) as well as extracting in aqueous two-phase system (ATPS). Collagenolytic protease production was performed in using MS-2 culture medium (SF) and soybean bran as substrate (SSF). Subsequently, the fermented liquid from both fermentations were used for the extraction of enzyme by ATPS, it was verified the influence of different variables from a factorial design 23. In SSF the highest protease and collagenolytic activities were achieved with 362.66 U/mL and 179.81 U/mL, respectively. When compared with SF (26.33 and 18.70 U/mL) higher values were obtained in the activities. The protease partitioning from SF and SSF in ATPS showed a similar profile showing higher affinity for the polymer rich phase. The highest value for the response variable purification factor (3.49) was obtained in the system using SSF. Thus, SSF shows promise as a bioprocess for extracellular production of collagenolytic proteases, using of soybean bran as substrate had used sustainable raw material, aiming application this possible enzyme in the treatment of burns and postoperative scarring.

Abstract The industrial demand for proteolytic enzymes is stimulating the search for new enzyme sources. Fungal enzymes are preferred over bacterial enzymes, and more effective and easier to extract. The aim of this work was to evaluate the potential of protease production by solid state fermentation (SSF) of Mucor subtilissimus UCP 1262, evaluate different specific activities, purify and partially characterize the enzyme in terms of biochemical as to the optimal pH and temperature. Initially, the enzyme crude extract was screened for 3 different proteolytic activities, collagenolytic (161.4 U/mL), keratinolytic (39.6 U/mL) and fibrinolytic (26.1 U/mL) in addition to conventional proteinase activity. After ammonium sulfate precipitation, the active fractions with fibrinolytic activity were dialyzed in 15 mM Tris-HCl buffer, pH 8, loaded onto DEAE-Sephadex A50 ion-exchange column and gel filtrated through Superdex 75 HR10/300. The enzyme showed a fibrinolytic maximum activity at 40 C and pH 9,0. The purified enzyme showed activity against a chromogenic chymotrypsin substrate, SDS-PAGE showing a molecular mass of approximately 70 kDa and, the specific activity of 25.93 U/mg. These characteristics suggest that the enzyme could be and efficiently produced in a simple and low-cost way using Mucor subtilissimus UCP 1262 in SSF.

Abstract Copaiba oil is a natural product used by Amazonian populations and recognized for its medicinal properties because it has significant antimicrobial activity for several pathogenic microorganisms. The present work aimed to evaluate and characterize the effect of natural oil produced by copaiba – Copaifera multijuga against multiresistant isolates of bubaline mastitis. The nitrocefin test was performed with isolates of Staphylococcus aureus from bubaline mastitis, which were 100% positive for beta-lactamase enzyme detection. Minimum Bactericidal Concentration (MBC) of 25% to 3.12% was obtained for Enterococcus faecalis and Escherichia coli and 50% and 25% for S. aureus, but Klebsiella pneumoniae and Bacillus subtilis were resistant. MBC with 12.5% and 6.25% oil were obtained for most multiresistant bubaline mastitis isolates from the states of Pernambuco, Ceará, Bahia and Alagoas. The results demonstrated the great potential of using copaiba natural oil in the treatment of buffalo mastitis.

Resumo: A mastite é uma inflamação na glândula mamária que pode acarretar perdas na produção e na qualidade do leite, gerando prejuízos econômicos para a pecuária leiteira. O tratamento é baseado na utilização de antibióticos, sendo, em muitos casos, ineficazes devido à resistência bacteriana já conhecida para esta doença. O objetivo deste trabalho foi selecionar linhagens de Streptomyces spp. produtoras de biocompostos com atividade antimicrobiana frente a isolados do gênero Staphylococcus multirresistentes de búfalas com mastite. Bem como, determinar os melhores parâmetros de produção, e avaliar a produção simultânea de ácido clavulânico. A seleção de Streptomyces spp. com capacidade de produzir compostos com atividade antimicrobiana foi realizada através da técnica bloco de gelose. Dentre as 30 espécies de Streptomyces spp. testadas, o micro-organismo Streptomyces parvulus DPUA 1573 apresentou melhores resultados, sendo capaz de inibir o crescimento de 7 isolados Staphylococcus spp. multirresistentes. Posteriormente, a espécie selecionada Streptomyces parvulus DPUA 1573 foi cultivada em diferentes condições pré-determinadas pelo planejamento fatorial 24, onde as variáveis independentes foram: concentração de soja (0,5; 1,0; 1,5%), glicose (0; 0,5; 1g/L), agitação (150; 200; 250rpm) e temperatura (28; 32; 37°C) e todos os ensaios do planejamento foram monitorados até 120 horas de cultivo. Todas as variáveis independentes influenciaram positivamente no crescimento celular, enquanto que para atividade antimicrobiana apenas as variáveis temperatura e agitação apresentaram efeitos significativos positivos. O líquido metabólito produzido por Streptomyces parvulus DPUA 1573 foi capaz de inibir o crescimento de sete Staphylococcus spp. multirresistentes. As melhores condições de cultivo para a produção de moléculas bioativas por este micro-organismo foi a 37?C, com 250rpm de agitação por período de 72 horas. Nos ensaios que apresentaram atividade antimicrobiana, foi avaliada a produção de ácido clavulânico ao longo do cultivo. A maior concentração de ácido clavulânico foi de 269,84g/L obtidas nas condições de 1,5% de farinha de soja em ausência de glicose no tempo de 96 horas. A linhagem Streptomyces parvulus DPUA 1573 foi eficiente contra Staphylococcus spp. multirresistentes isolados de mastite em búfalas, ainda apresentando concomitantemente produção de ácido clavulânico com o potencial uso farmacêutico.

Abstract: Mastitis is an inflammation in one or more mammary glands which can lead to reduction in production and quality of milk causing economic losses to dairy farming. The use of antibiotics is the key for the treatment of this disease, but in many cases ineffective due to bacterial resistance already known for this condition. The aim of this study was to select strains of Streptomyces spp. producing biomolecules with antimicrobial activity against multidrug-resistant Staphylococcus isolated from buffaloes with mastitis, as well as to determine the best production parameters to the evaluation of simultaneous production of clavulanic acid. Thirty species of Streptomyces spp. were used to selecting the greatest producer spectrum of antimicrobial activity (agar block technique), with selection of Streptomyces parvulus DPUA 1573, and 7 multidrug-resistant Staphylococcus spp. sensitive to its biocompounds. The selected strain of Streptomyces parvulus DPUA 1573 was cultured in different conditions predetermined by the factorial design 24, where the independent variables were: soybean concentration (0.5, 1.0, 1.5%), glucose (0, 0.5, 1g/L), agitation (150, 200, 250rpm) and temperature (28, 32, 37°C); all the tests were monitored up to 120 hours of cultivation. All independent variables influenced positively the cell growth, while for antimicrobial activity only the variables temperature and agitation showed positive effects. The antimicrobial bio compounds showed activity against seven multidrug-resistant Staphylococcus spp under the conditions: temperature 37°C, agitation 250rpm, with 72 hours of production process. In the tests which showed antimicrobial activity, was also assessed the production of clavulanic acid along with the cultivation. The highest concentration of clavulanic acid was 269.84g/L obtained under the conditions of 1.5% of soybean flour and absence of glucose in 96 hours. The strain Streptomyces parvulus DPUA 1573 was effective against multidrug-resistant strains of Staphylococcus spp. of mastitis from buffaloes, still showing concomitantly production of clavulanic acid for pharmaceutical use.

RESUMO A trombose é uma doença patofisiológica causada pelo acúmulo de fibrina no sangue. Proteases fibrinolíticas com potente atividade trombolítica são produzidas por diversas fontes microbianas. Considerando a biodiversidade microbiana da região amazônica, o presente estudo teve como objetivo a seleção, produção e caracterização bioquímica da enzima fibrinolítica de Streptomyces sp. isolado de líquens da Amazônia. Streptomyces DPUA1576 foi a melhor produtora com atividade fibrinolítica de 283 mm2. Três variáveis em dois níveis foram utilizadas para determinar as variáveis mais relevantes na produção da enzima fibrinolítica (FA). Os parâmetros estudados foram agitação (0.28 - 1.12 g), temperatura (28 - 36 ºC) e pH (6.0 - 8.0) e todos obtiveram efeitos significativos na produção fibrinolítica. A maior atividade fibrinolítica (304 mm2) foi obtida a 1.12 g, 28 ºC e pH 8.0. O extrato bruto da fermentação foi usado para determinar as propriedades bioquímicas da enzima. Atividades proteásica e fibrinolítica foram estáveis durante 6 horas no intervalo de pH entre 6.8 - 8.4 e 5.8 - 9.2, respectivamente. Temperatura ótima para a atividade proteásica foi entre 35 - 55 °C, enquanto que para a atividade fibrinolítica foi de 45 ºC. Atividade proteásica foi inibida por íons Cu2+ e Co2+, fluoreto de fenilmetilsulfonil e pepstatina A, na qual sugere que a enzima é uma serino-protease. O extrato enzimático degradou o fibrinogênio nas subunidades Aα, Aβ e γ. Os resultados apresentados indicam que Streptomyces sp. DPUA 1576 produz enzimas com atividade fibrinolítica e fibrinogenolítica, enzimas com aplicações importantes na indústria farmacêutica.

ABSTRACT Thrombosis is a pathophysiological disorder caused by accumulation of fibrin in the blood. Fibrinolytic proteases with potent thrombolytic activity have been produced by diverse microbial sources. Considering the microbial biodiversity of the Amazon region, this study aimed at the screening, production and biochemical characterization of a fibrinolytic enzyme produced by Streptomyces sp. isolated from Amazonian lichens. The strain Streptomyces DPUA1576 showed the highest fibrinolytic activity, which was 283 mm2. Three variables at two levels were used to assess their effects on the fibrinolytic production. The parameters studied were agitation (0.28 - 1.12 g), temperature (28 - 36 ºC) and pH (6.0 - 8.0); all of them had significant effects on the fibrinolytic production. The maximum fibrinolytic activity (304 mm2) was observed at 1.12 g, 28 ºC, and pH of 8.0. The crude extract of the fermentation broth was used to assess the biochemical properties of the enzyme. Protease and fibrinolytic activities were stable during 6 h, at a pH ranging from 6.8 to 8.4 and 5.8 to 9.2, respectively. Optimum temperature for protease activity ranged between 35 and 55 °C, while the highest fibrinolytic activity was observed at 45 ºC. Proteolytic activity was inhibited by Cu2+ and Co2+ ions, phenylmethylsulfonyl fluoride (PMSF) and pepstatin A, which suggests that the enzyme is a serine protease. Enzymatic extract cleaved fibrinogen at the subunits Aα-chain, Aβ-chain, and γ-chain. The results indicated that Streptomyces sp. DPUA 1576 produces enzymes with fibrinolytic and fibrinogenolytic activity, enzymes with an important application in the pharmaceutical industry.

Background Streptomyces sp. DPUA 1576 from Amazon lichens was studied to protease and fibrinolytic production. A 2² factorial experimental design was applied to optimize its protease enzyme production using two independent variables, namely soybean flour and glucose concentrations. Results The optimal conditions to obtain high protease production (83.42 U/mL) were 1.26% soybean flour and 1.23% glucose concentration. A polynomial model was fitted to correlate the relationship between the two variables and protease activity. In relation to fibrinolytic activity, the highest activity of 706.5 mm² was obtained at 1.7% soybean flour and 1.0% glucose concentration, which was 33% higher than plasmin. Fibrinolytic production was not optimized in the studied conditions. Conclusions These results show that the optimization of the culture medium can enhance protease production, thus becoming a good process for further research. In addition, Streptomyces sp. DPUA 1576, isolated from Amazon lichens, might be a potential strain for fibrinolytic protease production.

This study aimed to identify antioxidant peptides from caprine casein hydrolysates by papain application using MALDI-TOF mass spectrometer, and a 2² full factorial design, with 4 axial points, in order to evaluate kinetic parameters (time and pH) effects on the degree of hydrolysis as well as the antioxidant activity of Moxotó goat milk casein peptides. Degree of hydrolysis was determined by total and soluble protein ratio in casein. Antioxidant activity was measured by ABTS method with 2, 2-cation-azinobis (3-ethylbenzothiazoline-6-sulfonic acid). TROLOX was used as standard. Peptide pattern and sequence of antioxidant amino acids were obtained using MALDI-TOF/MS. The highest degree of hydrolysis (28.5%) and antioxidant activity (2329.6 mmol.L TROLOX. mg- 1 peptide) were observed in the permeate. NENLL, NPWDQVK and LLYQEPVLGPV peptides, detected in the permeate, were pointed as the responsible for antioxidant activity, suggesting their potential application as food supplement and pharmaceutical products.

Enzymes obtained by fermentation processes offer a number of advantages and have been widely researched and used throughout the world. This study aimed to partially characterise an inulinase produced from palm and cassava peel. The enzyme was produced via the solid-state fermentation of Aspergillus japonicus URM5633. The optimal temperatures were 50ºC and 55ºC, and the optimal pH values were 5.2 and 3.4 for inulinase fermentatively produced from palm and cassava peel, respectively. The thermostability measurements for inulinase produced in palm showed that the relative activity remained below 100% until 30 minutes of stability for all temperatures, but reached 106.8% at a temperature of 50ºC after 60 minutes. Inulinase from the crude extract of cassava peel was pH stable and only decreased to 55% of the maximal activity over the course of the assay, suggesting that this enzyme can be used in inulinase production and can be utilized in food industries.

CONTEXTO: A tradução e a adaptação cultural são etapas que permitirão que um instrumento criado em determinado idioma e cultura possa ser usado em outro contexto cultural. O Charing Cross Venous Ulcer Questionnaire (CCVUQ) é um questionário de qualidade de vida em portadores de úlceras venosas que para ser utilizado no Brasil é necessária a execução do processo de adaptação transcultural. OBJETIVO: Traduzir e adaptar culturalmente para a população brasileira o CCVUQ. MÉTODOS: O processo consistiu em duas traduções e duas retrotraduções realizadas por tradutores independentes, da avaliação das versões, seguida da elaboração de versão consensual e de pré-teste comentado. RESULTADOS: No processo de tradução, algumas palavras foram modificadas no seu aspecto literal. A análise posterior dos resultados do pré-teste apontou necessidades de modificações de alguns termos para melhor compreensão do respondente. O tempo médio de aplicação do questionário foi de 5 minutos e 23 segundos. CONCLUSÃO: A versão na língua portuguesa do Charing Cross Venous Ulcer Questionnaire foi traduzida e adaptada para uso na população brasileira.

BACKGROUND: The translation and cultural adaptation are steps that will allow an instrument created in a particular language and culture might be used in another cultural context. The Charing Cross Venous Ulcer Questionnaire (CCVUQ) is a quality of life questionnaire in English for patients with venous ulcers that need to be translated and culturally adapted to be used in Brazil. OBJECTIVE: To translate and culturally adapt to the Brazilian the CCVUQ. METHODS: The process consisted of two translations and two back translations performed by freelance translators, evaluation of versions, followed by the development of consensus version and pre-test commented. RESULTS: In the process of translating some words and expressions were changed in its literal aspect. Pre-test evaluation indicated changes were needed for better understanding of the respondent. The average time to respond to the questionnaire was 5 minutes and 23 seconds. CONCLUSION: The Portuguese version of the Charing Cross Venous Ulcer Questionnaire was translated and adapted for use in Brazilian population.

A full two-level factorial design was employed to study the influence of PEG molar mass (MM PEG), PEG concentration (C PEG) and phosphate concentration (C PHOSPH) on proteases partition by Lentinus citrinus DPUA 1535 in a PEG/phosphate aqueous two-phase system (ATPS). For all ATPS studied, proteases partitioned for the top phase and the best proteases extraction condition was obtained with MM PEG = 6000 g mol-1, C PEG = 17.5% (w/w) and C PHOSPH = 25% (w/w) with (1.1) purification factor and (151%) activity yield. Findings reported here demonstrate a practical strategy that serves as a first step for proteases purification from crude extract by L. citrinus.

O objetivo deste trabalho foi determinar as variáveis que influenciam a produção simultânea de celulases e xilanase por Aspergillus aculeatus URM 4953 e A. phoenicis URM 4924, com uso de bagaço de cana-de-açúcar como substrato. As variáveis avaliadas foram pH inicial, tempo de cultivo, concentração do substrato, agitação, concentração do inóculo, temperatura, tipo de bagaço de cana-de-açúcar e espécie de Aspergillus. Foi utilizado o planejamento fatorial fracionário 2(8-4), com três repetições no ponto central. Todas as variáveis analisadas influenciaram a produção de pelo menos uma das enzimas. As maiores atividades enzimáticas observadas foram: celulases totais, 0,45 UI mL-1; endoglucanase, 0,60 UI mL-1; exoglucanase, 0,17 U mL-1 ; celobiase 6,42 UI mL-1; e xilanase, 30,05 U mL-1. As melhores condições para produção das enzimas foram: pH 6,0; tempo de cultivo de 168 horas; bagaço de cana-de-açúcar residual como substrato; e A. aculeatus URM 4953, que produziu as celulases e a xilanase simultaneamente. As variáveis que influenciam a produção simultânea das celulases e xilanase são pH, tempo de cultivo, tipo de bagaço de cana-de-açúcar e espécie de Aspergillus.

The objective of this work was to determine the variables that influence the simultaneous production of cellulases and xylanase by Aspergillus aculeatus URM 4953 and A. phoenicis URM 4924, using sugarcane bagasse as substrate. Initial pH, cultivation time, substrate concentration, agitation, inoculum concentration, temperature, sugarcane bagasse type and Aspergillus species were the variables evaluated. It was used the 2(8-4) fractional factorial design, with three replicates in the central point. All analysed variables influenced at least one of the enzyme production. The highest enzymatic activities were: total cellulases, 0.45 UI mL-1; endoglucanase, 0.60 UI mL-1; exoglucanase, 0.17 U mL-1; cellobiase, 6.42 UI mL-1; and xylanase, 30.05 U mL-1. The best conditions for enzyme production were: pH 6.0; cultivation time of 168 hours; residual sugarcane bagasse as substrate; and A. aculeatus URM 4953, which produced simultaneously all the cellulases and xylanase. The variables that influence the simultaneous production of cellulases and xylanase are pH, cultivation time, sugarcane bagasse type, and Aspergillus species.

O objetivo deste trabalho foi avaliar os efeitos da temperatura, pH, relação enzima:substrato (E:S) e tempo de reação sobre a hidrólise enzimática da caseína do leite de cabra Moxotó, com uso de diferentes enzimas proteolíticas. A hidrólise enzimática da caseína caprina foi realizada com uso de tripsina, pepsina e papaína. Para cada enzima, foram utilizados dois níveis de cada variável, na avaliação de seus efeitos sobre a hidrólise da caseína, em um fatorial completo 2(4). Os produtos da hidrólise foram visualizados em eletroforese SDS-PAGE. O melhor valor do grau de hidrólise com a enzima papaína foi obtido em pH 6,5, E:S de 1:150 e 5 horas de hidrólise a 50ºC (28,17%); com a tripsina, em pH 8,5, E:S de 1:150 e 5 horas a 40ºC (29,55%); e com a pepsina, em pH 3,0, E:S de 1:100 e 5 horas a 40ºC (38,27%). A hidrólise da caseína caprina é influenciada positivamente pelo pH e tempo de hidrólise, com o uso da pepsina. Foram observadas interações significativas antagônicas entre pH e relação E:S, com o uso da tripsina; e entre pH, temperatura e tempo de hidrólise, com o uso da papaína. A pepsina apresenta elevada eficiência na hidrólise de αs1, β e κ-caseína, evidenciada por hidrolisados com massa molar abaixo de 14,4 kDa.

The aim of this work was to evaluate the effects of temperature, pH, enzyme:substrate ratio (E:S), and reaction time on the enzymatic hydrolysis of Moxotó breed goat's milk casein, using different proteolytic enzymes. Enzymatic hydrolysis of the capric casein was performed using trypsin, pepsin and papain. For each enzyme, two levels of the variables were used to assess their effects on the hydrolysis of casein, using a full factorial design (2(4)). The hydrolysis products were visualized on SDS-PAGE. The best hydrolysis degree using papain were at pH 6.5, E:S of 1:150 and 5 hours of hydrolysis at 50°C (28.17%); for trypsin, at pH 8.5, E:S of 1:150 and 5 hours at 40°C (29.55%); and for pepsin, at pH 3.0, E:S of 1:100 and 5 hours at 40°C (38.27%). Capric casein hydrolysis is affected positively by pH and reaction time, using pepsin. Significant antagonistic interactions were observed between pH and E:S, with trypsine; and between pH, temperature and reaction time, with papain. Pepsin has high αs1, β e κ-casein hydrolysis efficiency, evidenced by the molar masses below 14.4 kDa of its products.

Clostridium perfringensé uma bactéria anaeróbia Gram-positiva, amplamente distribuída no meio ambiente e comumente encontrada no intestino de animais, incluindo o homem. As espécies de C. perfringensestão classificadas em cinco tipos toxigênicos (A, B, C, D, E) em função da produção de quatro toxinas (±, ², µ, ¹). Entretanto, as toxinas teta, delta, lambda e enterotoxina são também sintetizadas por outras espécies dessa bactéria. Muitas metodologias para purificação das toxinas produzidas por C. perfringens têm sido propostas e, portanto, nesta revisão foram apresentados e discutidos os métodos e resultados de purificação dessas toxinas relatados nas últimas quatro décadas.

Clostridium perfringens, a Gram-positive anaerobic bacterium, is widespread in the environment and commonly found in the intestines of animals, including humans. C. perfringens strains are classified into five toxinotypes (A, B, C, D and E) based on the production of four major toxins (±, ², µ, ¹). However the toxins (theta, delta, lambda and enterotoxin) are also synthesized by C. perfringens strain. Many attempts to purify the toxins produced by C. perfringens have been proposed. In this review we discuss the purification methods used to isolate toxins from C. perfringens reported in last four decades.